Yes, you can mount a T&P relief valve for a residential water heater horizontally, as long as the discharge piping slopes slightly downward to meet the requirements of the International Residential Code (IRC) and the Florida Building Code, Residential Edition (FBC P2804.6.1), that the discharge piping drain by gravity and not be trapped (not have any standing water remaining in pipe after draining).
T&P relief valves (sometimes called TPR valves) mounted on the side of a water heater can also discharge horizontally if necessary, although they typically discharge vertically downward. Again, the only requirement is that the valve pitch at least slightly downward for full drainage through the discharge piping. Some industrial pressure relief valves are specifically rated to only drain vertically downward, but the technical department of Watts Water Technologies, a leading manufacturer of these residential water heater valves, recently verified for us that horizontal discharge is allowed.
See our blog post What are the most common installation mistakes with water heater replacement? for examples of incorrect TPR valve installation, along with other installation errors, most of which are safety concerns.
• • • • • • • • • • • • • • • • • • • • • • • • • • • • •
Here’s links to a collection of more blog posts about WATER HEATERS:
• Are water heaters required to be raised off the floor?
• What does ECO INSTALLED mean on a water heater data sticker?
• Where are gas water heaters not allowed to be installed?
• Is the minimum size water heater inlet pipe 1/2" or 3/4" according to the building code?
• Can you use a light switch for a water heater disconnect?
• How can I tell if a water heater is HUD-approved for mobile/manufactured homes?
• Can you wire a 240-volt water heater with 120 volts?
• Is it alright to have a shut-off valve on both the hot and cold water pipes at a water heater?
• What is the minimum clearance to doors and windows for an outdoor tankless gas water heater?
• What is required clearance for access and working space in front of an electric water heater?
• Why is the water heater older than the house?
• Does a water heater need a shut-off valve?
• Why should a tankless water heater have an isolator/service valve kit installed?
• When was a gas water heater first required to be elevated 18 inches above a garage floor?
• Can the temperature and pressure relief (TPR) valve discharge pipe for a mobile/manufactured home water heater terminate under the home?
• What is the purpose of a thermostatic mixing valve above a water heater?
• Does a tankless gas water heater still work with no electricity during a power outage?
• Why do water heaters have a sacrificial anode?
• What is the difference between a manufactured/mobile home water heater and a regular water heater?
• Does a tankless water heater require a pressure relief valve?
• When is a water heater drain pan required?
• Why is there water in my water heater drain pan?
• What does it mean when a water heater Temperature/Pressure Relief (TPR) discharge pipe is "trapped"?
• Can I leave a gas water heater in place when remodeling a garage into a family room or bedroom?
• Where do I find the water heater in a mobile home?
• Does a tankless water heater in an attic require a drain pan?
• Does an electric water heater require a disconnect?
• Is a catch pan and drain piping required for a replacement water heater?
• What is the difference between a single element and dual element electric water heater?
• What is an FVIR water heater?
• What is a heat pump water heater?
• How can I determine the age of a water heater if the serial number is missing or decoding it is impossible?
• How does a hydronic heating system work?
• What is the difference between a regular water heater and a direct vent water heater?
• What is the difference between a regular water heater and a power vent water heater?
• What is backdrafting at a gas water heater?
• How do I determine if a water heater is gas or electric?
• What does it mean when a gas appliance (water heater, furnace, or range) has been "red tagged"?
• What's the valve with the flip-up handle on the water heater for?
• Why is an older water heater an insurance problem?
Visit our WATER HEATERS page for other related blog posts on this subject, or go to the INDEX for a complete listing of all our articles.